How to rectify your VAG group 1.2 tsi engine that has the EPC light comes on and lack of power when accelerating first check that the boost pressure actuator is not seized check if it’s moving if not replace it and if that doesn’t cure it you will have to replace the turbo charger links in the video of how to carry out this process tanks for watching
Смотреть в источнике
24 комментария
good afternoon. what was the problem? were there any mistakes?
Worst audio ever
hello, i had the same problem in my car, wesgeyt has changed, now we connected it to the machine, it gives a turbo failure p334B00 turbo charger supply golf 1,2 tsi
The service offered turbo repair for the epc problem, what do you think is the problem, although weskeyt and valve were made
Thanks for the great info, did this engine had a lot of miles on it?
Nice video, i have the cbzb engine 1.2 tsi and a p0049 fault, could it be the actuator, and should it be complete close when the car is of? Thanks in advance.
Sharing is very nice, but where can we find the actuator?
Where did you get the actuator
hi sir, pavan from Bangalore
I have 1.2 polo TDI 2011 model. Turbo actuator is not working and white smoke is coming from silencer
mechanic told Turbo Actuator is problem now waht is the problem pls let me know
Watting for your repaly
Is it possible to remove the actuator without removing the turbocharger?
Hello sir I got seat ibiza fr 2021 1 ltr and got on dash particulate filter regeneration required consult vehicle wallet. Can u give me advice please thanks
How do you diagnose this? I have this problem?
My 2015 1.2 tsi Skoda Yeti doesn't have any faults. However, when accelerating from rest, the turbo doesn't kick in the first 3 seconds. Could that be a sign of a failed waste gate?
how you fix ? change all part ? thanks
I’m a mechanic and my mums has went on her polo don’t have the car here with me . The light takes about 10 min to come on when your driving the car they are saying what’s the chances I can get it out with the turbo in place and what’s the odds that a good clean and high temp grease will revive it without me having to make them buy a new one ?
Hi, I have a problem my polo 2016 1.2tsi bmt dsg. 53000km I just bought this car . Epc light warning and start-stop faulty is always on display. And I find in faulty code OBD2 05463 (P1557) Charge Pressure Control: Positive Deviation. And I think car is not in limp mode, performance is good for me. Can you a advise ?
Hi Just stripped out to find pin seized in boost flap lever,,, un siezed 200 miles later siezed again ????????????
For anyone that has EPC & engine light on and code P00AF… Just fixed mine with some brute force and WD-40.
So if you lean right over the engine you should be able to see the actuator pin just tucked away behind the engine.
If you grab the pin with your right hand and pull it over to the right, whilst simultaneously twisting the pivot side with your left hand, you can get it to unstick. Top tip: do this dry first as you'll need all the grip you can get. There is a point on the actuator rod that it gets wider, grip this area and pull to the right while twisting the other side. Not sure which direction to twist. Do both. If you've got movement, great. Spray WD-40 using one of those cans with the straw. Spray directly on the pin itself where it goes into the housing, spray all over the pivot end. Give it 5-10 mins to penetrate. Repeat the yanking & twisting to lube her up. Spray some more WD-40 for good measure and start the engine. EPC light & engine light should go OFF if it's moving and unstuck and your car turbo boost should be working again.
Oh and P.S do this while the engine is COLD. Despite being stuck the pivot end gets red hot
Hi great video thanks, what purpose has the big hole right by the cold side turbin that connects to the motor?
Hi i only have my epc light indicatin on the dash wen i scanned it showed that my wastegate actuator is faulty and if i replace it will my car come out of limp mode? Was it the same for u
Hi, I have a Škoda Fabia 2017 1.2 TSI. The car drives fine and has no fault codes. Although I have a rattle off throttle which I believe to be to do with the turbo. Is this something that sounds familiar to this problem in the video?
Y cuando marca el codigo p02299 que falla es?
From the US here. 2013 beetle R-Line 2.0t CPLA engine . All the shop guides say replace entire turbo with air charge actuator, part V465. Can I do this with my Beetle
La válvula negra.. wastegate la que va ensamblada en el.turbo también se puede dañar y ahí que se hace